Home > categories > Machinery & Equipment > Forklifts > How to start a forklift? Say detailed point
Question:

How to start a forklift? Say detailed point

How to start a forklift? Say detailed point

Answer:

Check for safety around forklifts: make sure there is no one around your forklift before starting a forklift truck. When a large cargo is carried, when the eye is not good, please turn the car or be guided by others. When driving backwards, make sure there is no one around the forklift. When driving a forklift in a narrow passageway, you should be guided. Drivers should stop at the crossroads or other areas of sight to make sure that they drive when they are empty. Unlike a car, a forklift is a rear wheel that moves toward a turning point, lowering the speed and then turning the steering wheel to turn the back of the forklift. Be aware of pedestrians, obstacles and potholes, and notice the clearance above the forklift truck. Upper and lower forklift: stop jumping and jumping off the forklift truck. As you go up and down the car, grab the handle and step on the pedal. You can't grab a steering wheel or a joystick when you're driving up and down. Forklifts are forbidden: forks and pallets are strictly prohibited. Do not allow anyone other than the driver to ride. Don't replace the balance by employing people. Start the power with the key and see if the dashboard is normal: Check if the vehicle is empty;
Turn the key clockwise and start the engine; First notice the cargo fork: the control lever of the operating door is raised about 300 mm from the ground, and then the door frame is tilted forward to move. Step down the clutch control panel and move forward the back control lever and the gear stop. Slowly release the clutch pedal completely; Forbidding wild driving: don't turn on the key switch when stepping on the accelerator pedal. Do not suddenly start, brake or turn to prevent the fall of the cargo. Don't run over the barriers or obstacles that litter the road. Don't get into the soft ground; When driving on a wet, slippery, uneven or sloping road, please lower your driving speed. Make sure there is a gap between the door frame and the roof and the entrance.
Before leaving the forklift: the door stands slightly forward, and the cargo fork naturally lowers; If a cargo fork does not fall to the ground, there is a danger of stumbling and harming the body; The direction handle is in the neutral position; Pull on the brake handle; Turn off the key and remove the key. Parking in designated places: the parking area must be strong enough; Stop where traffic is safe; Not to park in the vicinity of fire hydrants and affect fire control passages; Stop at or near where inflammable substances are made; Don't park your car on the slope. Charge: to prevent the charging device from being damp, and the ventilation condition in charge of the charging station is better to emit the smell from the battery. When charging the forklift battery, be sure to mark the charge. When the battery is charged, the positive and negative are unable to take the reverse. Do not overdischarge, do not use the forklift truck to stop, when the battery capacity alarm is flashing, the battery needs to be charged. On the incline, Empty car up and down the slope - if the car is over the slope, it needs to be rolled back up and down the slope. The center of gravity will fall on the front wheel. Go up and down the slope.
Do not drive when the fork is raised: when the fork rises, do not drive the forklift truck, in case the goods are depraved. Do not drive on the side of the road: make sure the forklift has sufficient safety distance from the side of the road or platform to prevent the forklift from falling. Forklift maintenance: the forklift truck is not allowed to be modified, and the daily inspection and repair of the forklift is not allowed. When the forklift has any damage or failure, the forklift truck is stopped to be repaired; The forklift truck cannot operate a forklift truck until it is overhauled. When checking the electrical system, turn off the key switch and pull out the battery plug. When adding fuel, the driver should not be in the car, and the engine will be out of the fire. When checking the battery level of the battery or tank, don't fire the ignition. Avoid sudden start, quick start, sharp turn and sudden shift of direction, and stop the sudden acceleration. You should always do a forklift based on your surroundings. The control handle is not allowed to be controlled all of a sudden: the hydraulic control handle must be operated slowly, either in full load or in empty load. When a cargo fork is at a high point, a sudden manipulation of the handle can cause the risk of deterioration of the goods or the tipping of the forklift. Don't rush to the shelves. When the door is tilted forward, the shelf is forbidden to rise: when lifting a cargo or starting a forklift, the door frame should be put in place to stabilize the goods. Under fork condition, the door should not be tilted forward. When lifting or lifting the goods, they should stop first. When the forklift is tilted, do not unload the cargo.
Before leaving the forklift: the door stands slightly forward, and the cargo fork naturally lowers; If a cargo fork does not fall to the ground, there is a danger of stumbling and harming the body; The direction handle is in the neutral position; Pull on the brake handle; Turn off the key and remove the key. Parking in designated places: the parking area must be strong enough; Stop where traffic is safe; Not to park in the vicinity of fire hydrants and affect fire control passages; Stop at or near where inflammable substances are made; Don't park your car on the slope. Charge: to prevent the charging device from being damp, and the ventilation condition in charge of the charging station is better to emit the smell from the battery. When charging the forklift battery, be sure to mark the charge. When the battery is charged, the positive and negative are unable to take the reverse. Do not overdischarge, do not use the forklift truck to stop, when the battery capacity alarm is flashing, the battery needs to be charged. On the incline, Empty car up and down the slope - if the car is over the slope, it needs to be rolled back up and down the slope. The center of gravity will fall on the front wheel. Go up and down the slope.

Share to: